Author |
Topic: fans runing all the time (Read 428 times) |
|
the_machine
Full Member
I'm a YaBB newbie!
Posts: 121
|
 |
fans runing all the time
« on: Jul 28th, 2007, 2:54pm » |
 Quote  Modify
|
Hi Guys
Cossie fans on all time. both on. they come on about ten seconds after engine is running. but only when engine running.
not the air con compressor switch, tried disconnecting that they still run.
anyone know which relay runs the fans? 2 relays?
both fans are on, even when i switch off air con and even when engine cold.
a shorted realy?
anyone know where the wiring diagram is so i can trace the route back to source?
does the car have more than one coolant temperature sensor?
i.e a sensor just for the temp gauge , then a more sensitive sensor for the engine management?
perhaps the sensor is dead or bad wiring, i noticed some bad wires on the engine compartment engine loom, do you reckon a wire is short or open circuit giving false reading to ecu?
any tips help / diagrams / ideas greatly appreciated
pete
|
|
 IP Logged |
|
|
|
Snoopy
Administrator
Very old.BAD tempered and missing friends.
Posts: 6284
|
|
Re: fans runing all the time
« Reply #1 on: Jul 28th, 2007, 3:24pm » |
Quote Modify
|
Wiring diagrams in schematic form are HERE . Although the url says "sierra" they are the ford scorpio ones
|
|
IP Logged |
HELP the FORUM.Please DONATE
|
|
|
Jonnycab
Senior Member
Former owner of 2.3 Ultima Facelift saloon
Posts: 3900
|
|
Re: fans runing all the time
« Reply #2 on: Jul 28th, 2007, 8:30pm » |
Quote Modify
|
The fan relay is behind the drivers side headlamp....big green one 
|
|
IP Logged |
|
|
|
pete from Hull
Senior Member
Non Scorpio at the moment, but still interested...
Posts: 1365
|
|
Re: fans runing all the time
« Reply #3 on: Jul 28th, 2007, 11:09pm » |
Quote Modify
|
My fans were running all the time, since I have replaced aircon compressor, reciever drier and pressure switch they are not running all the time and the aircon is working brilliantly, is your aircon gassed enough/ too much?
Pete
ps I know mine is a 2.3 but I think the aircon is similar to yours....
I could be wrong..
|
|
IP Logged |
Bring back fair wages.........
|
|
|
davem
Full Member
A member since August 2000
Posts: 135
|
|
Re: fans runing all the time
« Reply #4 on: Jul 31st, 2007, 8:07pm » |
Quote Modify
|
Check http://www.fordscorpio.co.uk/coolfans.htm
for cooling fan operation. They are twin speed fans and will be on all the time on low speed if the aircon is on.
I know these fans very well...replaced 2 now...I would worry when they dont spin at all. On all the time? Lucky you ----Ignore it
but if it bothers you...check the above link for full details of how the fans work. The previous member is correct...its a large green relay behind the driver's side headlamp. In fact, the green cover is removeable and inside you will find 3 relays...2 small and one slightly larger.
You can safely operate these by hand by just squeezing the contacts together to test the fans individually, Note: In normal operation both fans always work together at the same speed....either off, low speed or high speed together. In other words, they run together as a matched pair...not individually...but to test them individually.....
From memory, with the engine and ignition off...squeeze one of the smaller relays..one fan will operate at low speed. Squeeze the other smaller relay, the other fan will operate at low speed. Squeeze the larger relay and a smaller one together and one fan will run at high speed. The other small relay in conjuction with the larger relay will operate the other fan at high speed. Squeeze all 3 relays together. you should get both fans at high speed.
Hope that helps.
Dave
|
|
IP Logged |
'95 Cosworth - 185,000 miles and still going
|
|
|
WAYNE
Newbie
I love YaBB 1G - SP1!
Posts: 43
|
|
Re: fans runing all the time
« Reply #5 on: Aug 1st, 2007, 7:24am » |
Quote Modify
|
Hi guys,
My fans were running all the time at start up,turned out to be the wiring to the engine coolant temp sensor,the larger one above the water pump.check that the insulation around the wires hasnt perrished or split and that bare wires arent touching together because this will cause both fans to run at high speed all the time.
Regards
Wayne
|
|
IP Logged |
|
|
|
the_machine
Full Member
I'm a YaBB newbie!
Posts: 121
|
|
Re: fans runing all the time
« Reply #6 on: Aug 3rd, 2007, 8:52pm » |
Quote Modify
|
thanks guys for all your tips, ill go investigate and report back
|
|
IP Logged |
|
|
|
the_machine
Full Member
I'm a YaBB newbie!
Posts: 121
|
|
Re: fans runing all the time
« Reply #7 on: Aug 5th, 2007, 11:39am » |
Quote Modify
|
WAYNE !!!!! THATS EXACTLY IT! FOUND IT JUST AS YOU SAID. REPAIRED!!!!!!! THE WIRES HAD SHORTED TOGETHER. INSULATION CRACKED OFF AND EXPOSED THE COPPER. RUNS PERFECT NOW. MANY THANKS EVERYONE
|
|
IP Logged |
|
|
|
|
Home
Help
Search
Members
Login
Reply
Send Topic
Print